投碱种类和氨吹脱对污泥碱性发酵产酸的影响

采用完全混合式厌氧反应器,比较了NaOH和Ca(OH)2 2种碱试剂对污泥厌氧发酵产酸的作用效果,结合氨吹脱作用考察了NH4+浓度的降低对各有机物水解酸化程度的影响.结果表明在pH值为10的条件下,以NaOH调节的体系中各种有机物尤其是挥发性脂肪酸(VFAs)的量明显高于以Ca(OH)2调节的体系.Ca(OH)2调节的体系中释放出的蛋白质有部分沉淀,磷酸盐含量也较低,小于40mg/L;氨吹脱的体系发酵液中氨氮含量减少了43%,增大了VFAs的积累量;在NaOH和氨吹脱的组合条件下,污泥水解酸化程度最好,SCOD为6732mg/L,蛋白质为2029mg/L,碳水化合物374mg/L,VFAs总量2545mg/L,且氨氮含量低于200mg/L;分析认为氨吹脱作用增大VFAs积累量的原因主要是NH4+浓度的减小,促进了产酸菌对于碳水化合物的发酵.     

Treatment of biologically treated effluents from baker's yeast industry by membrane and ozone technologies

This paper presents pilot‐scale membrane treatment results performed on biologically treated effluents from fermentation industry and ozone oxidation on concentrates from the same membrane treatment system. The results obtained from the ultrafiltration (UF) and/or the reverse osmosis (RO) systems indicate that membrane treatment are very effective for COD, Color, NH₃‐N and conductivity removal. Ozone oxidation of the membrane concentrates was tested to increase biodegradability of the wastes. The initial ratios of Biochemical oxygen demand (BOD₅) to Chemical oxygen demand (COD) were increased significantly by applying chemicaloxidation with O₃ and O₃ + H₂O₂.     

Optimization of anaerobic processes by speciation and bioavailability of trace metals

The deficiency trials of some trace metals (copper, nickel, zinc) were made in laboratory Upflow Anaerobic Sludge Blanket (UASB) reactors containing the inoculum of an industrial anaerobic sludge, a basal medium with the rest of nutrients and vitamins in comparison with a control reactor with the optimal doses of trace elements. From the main control parameters (alkalinity, acidity, DQO), no inactivation by deficit of essential elements was detected, but the control reactor showed greater mineralization and solid content, being necessary to make purge to avoid bulking. The inoculum has high metallic element contents, so the additional contribution produces high bacterial growth, also purge being necessary to avoid bulking. The purge, made after 120 days in continuous operation, eliminates a great quantity of solids and increases the volatile solids (VS)/total solids (TS) ratio. The comparison of the initial content of metallic elements in the solid and liquid phases with the contents after 120 days showed a progressive depletion of metals in all reactors without a clear appreciation of the lack of the studied metals. Finally, in 210 days, the reactors without addition of a metallic element accumulated greater quantity of major (Ca, Fe, Mg) and trace (Co, Ni, Cu) elements in the solid phase with respect to the control.     

Zn2+及Fe3+对嗜淀粉乳杆菌开放式发酵产乳酸的影响

研究了在餐厨垃圾中接种嗜淀粉乳杆菌进行开放式乳酸发酵(即发酵原料不灭菌)的可行性,探讨了添加Fe3+、Zn2+的发酵体系中相关酶活与代谢产物的关系.结果表明,开放式发酵体系的乳酸产量高于非开放式发酵体系.加Fe3+体系的乳酸脱氢酶活性较高,导致乳酸产量增加(最高达29.5g/L),比未添加微量元素的对照体系增加了24.2%;而加Zn2+体系的乙醇脱氢酶(ADH)活性较高,导致副产物乙醇产量的增加,从而使乳酸产量低于对照体系;添加不同微量元素时嗜淀粉乳杆菌对底物中淀粉的利用率由高到低的顺序为:加Fe3+体系(65.7%) > 对照体系 (38.5%)>Zn2+体系(28.1%).此外,在嗜淀粉乳酸菌的发酵体系中,蔗糖和麦芽糖比乳糖容易降解成葡萄糖,果糖,最终被乳酸菌利用.     

Performance and stability of an anaerobic fixed bed reactor subjected to progressive increasing concentrations of influent organic matter and organic shock loads

Data on the performance of a horizontal-flow anaerobic immobilized biomass (HAIB) reactor subjected to step increases of organic loading rates (OLR) and to organic shock loads (OSL) are presented and discussed. The tubular reactor (100 cm long and 5 cm diameter) with a useful volume of 1995 mL was filled with polyurethane foam cubic matrices holding immobilized biomass and fed with synthetic wastewater. The reactor was operated at the controlled temperature of 30+/-1 degrees C and hydraulic retention time of 7 h. After about 15 days, the HAIB reactor attained operating stability. Thereafter, it was subjected to step increases of the applied OLR that ranged from 6.8 to 18.8 kg COD/m(3)d. After steady state had been achieved at each step, OSL corresponding to approximately three times the operating OLR were applied for 7 h. No disturbance was observed due to the step increase in OLR. An increase in effluent chemical oxygen demand (COD) and volatile fatty acids (VFA) concentrations and a decrease in the percentage of methane in the biogas were observed due to OSL applications. However, stability of the monitoring parameters was always restored approximately 17 h after the application of OSL for all conditions tested.     

城市生活垃圾发酵制肥

本文以国内外的工程实践为基础,从技术和经济角度介绍城市生活垃圾中的可腐有机物发酵制肥的基本原理、好氧和厌氧发酵技术的工艺特点、适应条件、建设投资、资源回收和环境影响等。建议在我国经济发达的城市推广应用厌氧发酵制肥技术。     

复合式厌氧折流板反应器作为制氢系统的乙醇型发酵调控研究

乙醇型发酵被认为是产氢发酵类型中的最佳选择.以赤糖废水为底物,进行了五格室、总有效容积为43.2 L的复合式厌氧折流板反应器作为制氢系统的乙醇型发酵调控研究.为期64 d、3个阶段的实验结果表明,以好氧活性污泥作为接种污泥,在水力停留时间为12 h、进水pH为5.0~7.0之间、温度为35℃±1℃的条件下,通过分阶段提高进水COD的方式,可使HABR系统在启动阶段培育出具有稳定产氢效能的乙醇型发酵菌群体系.由于废水进入每一个格室的状态不同,每个格室形成的微生物菌群结构不同,虽然也都形成了乙醇型发酵,但是产氢能力有所差异,第二格室产氢量最高.系统第二阶段,COD为6500 mg·L-1时,平均COD去除率为43.34%,平均产氢量为14.91 L·d-1,此阶段效果最佳.在第三阶段,COD过高,系统产氢量与COD去除率出现下降,但产氢系统并没有崩溃.系统可同时生产氢和乙醇,其能量值在第二阶段达到最高值,平均为3340.62 kJ·d-1.在不同的COD条件下,氢气与乙醇生产速率的线性关系为y(氢)=0.351x(乙醇)-0.181(R2=0.9767).     

沼液中悬浮物对乙醇发酵的影响及其絮凝处理的研究

乙醇-沼气双发酵耦联工艺的应用有望实现乙醇工业工艺废水"零排放"的目标.本研究对该耦联工艺的回用配料水——中温沼液中的悬浮物对乙醇发酵的影响进行了考察,并对其去除方法进行了确定.结果表明,沼液中悬浮物的存在会促进酵母细胞的繁殖,提高发酵速率,但副产物甘油及小分子有机酸的量大幅上升,而主产物乙醇的生成量减少,悬浮物对乙醇合成的临界抑制浓度为0.35 g·L-1(干重).采用不同的絮凝剂及絮凝方式对沼液中的悬浮物进行去除,发现絮凝剂聚合氯化铝(PAC,300 mg·L-1)与阳离子聚丙烯酰胺(CPAM,2 mg·L-1)协同处理时效果最佳,对沼液浊度、色度的去除率分别为92.4%、23.7%,所得上清液的悬浮物粒径小于2μm,PAC、CPAM的残留量分别为0.82、0.03mg·L-1.絮凝处理后消除了悬浮物对乙醇合成的抑制作用,且絮凝处理后沼液回用的发酵性能略优于离心所得沼液回用的发酵水平,达到了预期的目的.     

Performance and microbial response during the fast reactivation of Anammox system by hydrodynamic stress control

Anaerobic ammonium oxidation （Anammox） has become a promising method for biological nitrogen removal. However, this biotechnology application is always limited due to the low growth rate and biomass yield of Anammox bacteria. This study investigated the process of fast reactivation of an Anammox consortium idled for 2 years uia hydrodynamic stress control. The results showed that the Anammox system was efficiently and quickly reactivated by shortening of the hydraulic retention time （I-IRT） of the reactor from 12 to 6 hr within 68 days of operation. Moreover, at a 4-hr HRT with an influent total nitrogen loading rate of 1.2 kg N/（m3.day）, the reactor maintained high biological performance with an ammonium removal loading rate of 0.52 kg N/（m3.day） and a nitrite removal rate of 0.59 kg N/（m3.day）. In the reactivated Anammox reaction, the stoichiometric coefficients of NH4-N to NOE-N and NH4-N to NO4-N were 1：1.04± 0.08 and 1：0.31 ± 0.03, respectively. The specific Anammox activity and hydrazine oxidoreductase activity, both of which represent the degree of Anammox bacteria present, increased as the hydrodynamic stress increased and were maximally （125.38 ± 3.01 mg N/（g VSS.day） and 339.42 ± 6.83 μmol/（min.g VSS）, respectively） at 4-hr HRT. Microbial response analysis showed that the dominant microbial community was obviously shifted and the dominance of Anammox bacteria was enhanced durinR the hydrodynamic selection.     

焦化废水厌氧氨氧化污泥培养影响因素的研究

针对煤化行业高含氮焦化污水,采用厌氧氨氧化工艺进行脱氮污泥培养、驯化,对可能制约厌氧氨氧化菌生长的因素进行研究分析。结果发现:得出适宜于厌氧氨氧化污泥培养的水力停留时间、温度、p H及为保持污泥活性要求限制反应器进水氨氮和亚硝酸盐氮的最大负荷值。